PERFORMANCE AIR FILTER INSTALL
Written by Mustangworld.
of pics, I hope your on the net at 28.8 or faster.
K & N Air filter
and cleaning kit . Filter $39,
Cleaning Kit $10. This is what comes in the box.
you want a little extra HP for under $50 ? Purchase a K & N Air Filter
! There are other performance filter manufacturers out there all using
the same basic principle to improve air flow...using cotton instead of
paper for air filtration. But remember, cotton alone will not work, you
also need a slight "film" of oil on the cotton to ensure the cotton grabs
all the dirt and grime. This oil gives the cotton a reddish / orange look.
Don't expect to "feel" a great increase in HP. Expect a stang that sounds
a bit louder at high rpms, revs up and down a little faster, has a little
more pickup coming out of turns and breathes easier. The HP gain depends
on your mods, but on a stock stang, I'd say from 2 - 4 HP. The 3.8L K&N
air filter is available at Chief Auto performance shops. They had it in
reason to buy a cotton filter is the ability to wash them and re-use them.
Some of us here live on dirt roads and we have to drive several miles
on dirt to get to our houses in the hills (this is where we also "rally
race" our stangs, like a bunch of Pikes Peak racers) the air filters get
real dirty, real quick. Without a K & N Air filter, we'd have to buy
2 filters a year just to maintain a clean intake. A cotton filter can
be washed and re-washed to work like new, for the life of your stang.
also purchase the K & N "Filter Charger" system for $89. This is a
system (includes a metal bracket and air filter) that completely replaces
your air box and runs the filter element completely exposed to maximize
air intake. Keep in mind that in some situations, an open air element
may get dirty faster than one that is inside a filter box. We just went
with the regular $39 air filter element alone, a stock air filter replacement,
because this project stang will see dirt road action almost every day.
We left our stock air box in place, but still removed the air silencer.
right part no. for your Stang. This particular application was: 1996 Mustang
3.8L V6 K & N Filter Part E-0940. Cleaning kit 99-5000.
HERE WE GO!
Here's the 3.8L Air filter box. We've already removed
the air silencer, so replacing the air filter is a piece of
cake. With the air silencer in place, it's more difficult because
the air silencer goes into the fender well about 10" or so. We only
have to remove one bolt and a latch, I'm un-bolting it here.
Now we must un-latch the 2 latches that hold the
air box to the MAS air assembly. One's on top, one's on the side.
Next we'll pull the air box from the MAS air assembly.
Notice on the 3.8L there is a plastic TAB at the bottom (where my
pinky finger is) this means that we'll have to lift up and let the
air box drop out of this TAB before we can pull it off.
Now that the air box is out, remove the old filter.
Your new K & N comes pre-oiled, so all we need to do is drop
it in place. Also notice one of the two rubber grommets at the bottom
of the air filter, we'll need to line these up when we re-install
the air box.
Now just re-install the air box taking into account
the TAB and grommets we showed in the above steps. Re-latch the
2 latches. Then re-bolt the air box with the one bolt at the top
and you're done!
The kit comes with a sticker that says "STOP YOU
FOOL ! Don't throw away my air filter, I can re-use it !" It's wise
to stick it some place visible. We put ours on the metal space to
the left of the radiator, just next to the hood support on the passenger
side. Stickers don't stick to well to the air box itself. This is
in case you take your Stang in for service, you don't want the dudes
to trash your filter.
This is the $10 Cleaning kit that you use to clean
out your filter. When it gets dirty, you spray it down with this
cleaner, soak it for 15 minutes, hose it down, dry it, then re-oil
it with this oil. Your back in business. Every K & N filter
comes with a million mile warranty. You can wash your filter like
10 times with this kit.
totally done dede!....til next time.... see ya on the street !
the Mustangworld crest logo above and MOLLERNET are registered
trademarks of MoLLER DIGITAL / DiscMEDIA INC. Copyright ©
1986 - 1998 MoLLER DIGITAL. Some web elements on this site are
copyrighted and are being used with permission from their respective
owners. MUSTANGWORLD web elements may not be "re-posted" on any
website anywhere in the free world without permission from MoLLER
DIGITAL INC. All original graphics are digitally watermarked to
aid us in copyright enforcement.